codes from cel need help

Discussion regarding the software diagnostic solution

Moderator: Mikewire

codes from cel need help

Postby VWJET00 on Apr Sat 19, 2008 8:55 pm

okay so a buddy and me scanned my 2000 vw jetta vr6 today and i got the following codes. P0420, P0411, P1196, and P1137 pd. I figured out that the P0420 was prolly my engine temp sensor being that my temp gauge rarely comes up. P0411 is either my secondary air injection pump or selenoid valve *which i have no idea what this is!*, and P1196 is my pre cat 02 sensor. the last one i have no idea and i searched for it but had no luck if someone could help me out that would be great thanks a lot!
~VR6JET~
User avatar
VWJET00
Kicking the tires...

Kicking the tires...
 
offline
 
Posts: 68
Joined: Nov Thu 08, 2007 2:26 pm
Location: Billings, MT

Postby CBCGSXR1000 on Apr Sun 20, 2008 8:30 am

Did u us vag com it will tell u what each one is?
I will look it up later no time right now.
I have vag com if u want to swing by :thumbsup:
CHRIS
User avatar
CBCGSXR1000
In the drivers seat...

In the drivers seat...
 
offline
 
Posts: 556
Joined: Jul Thu 26, 2007 9:51 pm
Location: BILLINGS
Vehicles: 2

Postby Rennwagen1 on Apr Sun 20, 2008 11:01 am

Well, I am not sure what the rest of the codes are, but the secondary air pump is fairly common on the Vr6s, in fact I have the same problem. The pump pushed fresh air into some part of exhaust system on startup that helps the cat heat up faster so the 02 sensors do their job faster. Mine has been bad for about 3 years now, and the only problem it can lead to(other than the CEL being on) is premature cat failure, but I have not had any problems with it. One of these days I am going to fix it, but I haven't really felt like it for the last 3 years or so. Car runs perfectly, so I will get to is sometime.....
Jd3 wrote:Once again I was slangin rocks and pimpin bitches. Got a degree from the streets. Listen to the song regulate by warren g. I wrote it.

MikeWire wrote:Vanilla Ice > Depeche Mode.


Captain Pajama Shark
99% Awesome 100% of the time!!
1.8/2.8/3.2 OEM+
You can pay for school, but you can't buy class!
Image
User avatar
Rennwagen1
The Dubfather

The Dubfather
 
offline
 
Posts: 4166
Joined: Nov Mon 06, 2006 5:21 pm
Location: ZooTown Represent!
Vehicles: 84 GTI, 97 GLX, 04 Touareg V6

Postby Mikewire on Apr Sun 20, 2008 5:51 pm

Here you go Joel:

VAG-COM Version: Release 311.2-N


Chassis Type: 1J - VW G/J/B Mk4
Scan: 01,02,03,08,15,17,19,22,35,46,56

Address 01 -------------------------------------------------------
Controller: 021 906 018 M
Component: MOTRONIC ME7.1 G V006
Coding: 00031
Shop #: WSC 00066
1 Fault Found:
16804 - Catalyst System: Bank 1: Efficiency Below Threshold
P0420 - 35-00 - -
Readiness: 0000 1101

Address 03 -------------------------------------------------------
Controller: 1J0 907 379 AF
Component: ASR 20 IE CAN 0001
Coding: 13204
Shop #: WSC 00066
No fault code found.

Skipping Address 15-Airbags

Address 17 -------------------------------------------------------
Controller: 1J0 920 900 J
Component: A4-KOMBIINSTR. VDO V59
Coding: 07262
Shop #: WSC 02338
IMMO-IDENTNR: VWZ7Z0Y2186151
1 Fault Found:
01039 - Coolant Temperature Sensor (G2)
30-00 - Open or Short to B+

Address 19 -------------------------------------------------------
Controller: 6N0 909 901
Component: Gateway K<->CAN 0001
Coding: 00006
Shop #: WSC 00066
No fault code found.

Address 46 -------------------------------------------------------
Controller: 1J0 959 799 AJ
Component: 61 Zentral-SG Komf. 0001
Coding: 04096
Shop #: WSC 00066
2 Faults Found:
00912 - Window Regulator Switch: Front Left (E40)
27-10 - Implausible Signal - Intermittent
00944 - Heated Exterior Mirror: Passenger Side (Z5)
35-00 - -

End -------------------------------------------------------

2015 Audi Q5 2.0T Premium Plus
2005.5 VW Jetta TDI 5 speed
2001 Audi Allroad Quattro 2.7TT 6 speed manual swap
2001 VW Beetle 1.8T GLX 5 speed
1992 VW Montana Green GTI
1972 VW Kombi 9 Passenger Deluxe w/ 2.0L F.I. VWAC

FAQ | Forum rules
User avatar
Mikewire
Site Admin

Site Admin
 
offline
 
Posts: 4026
Joined: Oct Thu 20, 2005 1:23 am
Location: Billings, MT
Vehicles: Air and Water

Postby MK 4 GTI on Apr Sun 20, 2008 8:06 pm

420 is the universal code for CAT
2000 MK 4 GTI 1.8t
1994 Ford F-150 4X4
Beware of the green spec in your rearview.....You are about to get passed!
User avatar
MK 4 GTI
Kicking the tires...

Kicking the tires...
 
offline
 
Posts: 85
Joined: Jan Sun 27, 2008 11:17 am
Location: malden wa

Postby Rennwagen1 on Apr Mon 21, 2008 9:03 am

MK 4 GTI wrote:420 is the universal code for CAT

CATS that like the BONG!!

No, really, it doesn't say anything in there about the secondary air pump, though. :question:
Jd3 wrote:Once again I was slangin rocks and pimpin bitches. Got a degree from the streets. Listen to the song regulate by warren g. I wrote it.

MikeWire wrote:Vanilla Ice > Depeche Mode.


Captain Pajama Shark
99% Awesome 100% of the time!!
1.8/2.8/3.2 OEM+
You can pay for school, but you can't buy class!
Image
User avatar
Rennwagen1
The Dubfather

The Dubfather
 
offline
 
Posts: 4166
Joined: Nov Mon 06, 2006 5:21 pm
Location: ZooTown Represent!
Vehicles: 84 GTI, 97 GLX, 04 Touareg V6

Postby Mikewire on Apr Mon 21, 2008 9:25 am

16804 - Catalyst System: Bank 1: Efficiency Below Threshold

Is a code for the pre-cat O2 sensor. More diags are needed to diagnose the real problem with the sensor, but for $25 he can replace it, which probably needs to be done anyway considering his mileage.

He also should get the green top coolant sensor and the o-ring too. I'm not that familiar with where it is on the VR, and I could look it up but I would imagine that one of you guys would know where it's at and maybe explain it better.

Couldn't find anything on the SAI pump, so I figure it's a misdiagnosed code. Some of the early 00 models don't even have one, and I didn't verify that. I you need more help Joel let me know and we can meet up another night.

2015 Audi Q5 2.0T Premium Plus
2005.5 VW Jetta TDI 5 speed
2001 Audi Allroad Quattro 2.7TT 6 speed manual swap
2001 VW Beetle 1.8T GLX 5 speed
1992 VW Montana Green GTI
1972 VW Kombi 9 Passenger Deluxe w/ 2.0L F.I. VWAC

FAQ | Forum rules
User avatar
Mikewire
Site Admin

Site Admin
 
offline
 
Posts: 4026
Joined: Oct Thu 20, 2005 1:23 am
Location: Billings, MT
Vehicles: Air and Water

Postby VWJET00 on Apr Mon 21, 2008 10:57 am

for sure mike i have to wait until i get my tax return for those sensors but for graduation i get my exhaust from my dad i guess so im excited. now its just a matter of finding a cam and intake. lol hopefully summer is good the the getta! thanks for you help mike!
~VR6JET~
User avatar
VWJET00
Kicking the tires...

Kicking the tires...
 
offline
 
Posts: 68
Joined: Nov Thu 08, 2007 2:26 pm
Location: Billings, MT


Return to VAG-COM diagnostics

Who is online

Users browsing this forum: No registered users

cron